气溶胶发生器 TDA-4B
这是一款型的Tda-4B的气溶胶发生器。即适用于HEPA的过滤性能试验,也适用于使用尘埃粒子计数器进行的泄漏试验,只需要提供清洁的压缩空气即可进行工作。具有三个个调节阀,通过调整调节阀即可实现所发生浮游浓度的调整。
技术参数:
可使用的流量范围 | 50~8,100cfm (1.4-229m3min) |
发生浓度 | 10ug/L: 流量8,100cfm(约230m3/min时) |
100ug/L:流量810cfm(约23m3/min时) | |
测试精度 | 100ug/L:流量810cfm(约23m3/min时) |
发生粒子 | PAO、DOP、多分散 |
发生方法 | 1-6Laskin Nozzles |
压缩气体 | 3-18cfm (85-510L/min) 20psi (0.14Mpa) |
电 源 | 不需要 |
外形尺寸 | 约280x230x250mm |
重量 | 约7.3kg |
**适用20psi(0.14Mpa)的压力时 注:不建议采用DOP
TDA-4B Aerosol Generator
Printable Specification Sheet
Description
ATI manufactures portable Laskin nozzle aerosol generators which produce a sub-micron polydispersed oil mist aerosol in concentrations from 10 to 100 micrograms per liter (ug/l) at air flows from 50 to 8,100 cfm.
Aerosol generators and photometers are used to integrity test or locate leaks in high efficiency air filtration systems. Filter manufacturers use this equipment to scan ULPA and HEPA filters to verify they are free from manufacturing defects. Filter certifiers use this equipment to insure that filters were not damaged in shipping and have been installed properly, eliminating any leakage.
With the proper generator and photometer combination, filter deficiencies such as pinholes, thin spots, gasket leaks, frame leaks or seal problems can be quickly and quantifiably pinpointed and corrected thus protecting product and personnel.
Both the TDA-4B and the TDA-4BLite feature several improvements including rugged stainless steel construction, large fill port, individual nozzle control, and a 3" standard sanitary outlet fitting. An optional hose adapter, part # 9300100, is available for introducing the aerosol into positive pressure systems.
Features
The TDA-4B is the latest design in rugged, lightweight Laskin nozzle generators from ATI. The TDA-4B is a small, compact aerosol generator which requires only a supply of clean, compressed air to create polydispersed sub-micron oil aerosol.
The TDA-4B has 6 Laskin nozzles. Three valves permit the unit to be operated with 1 to 6 nozzles, providing a wide range of aerosol concentrations.
The TDA-4B is recommended for testing systems with air flows of 8,100 cfm and lower. It is ideal for work stations, Negative Pressure Filtration Units, biosafety cabinets, ceiling modules, small or portable cleanrooms, or HEPA filter units in installations where an adequate supply of clean, compressed air is readily available.
TDA-4B SPECIFICATIONS
- Aerosol Output Range: 50-8,100 cfm
- Aerosol Concentration 100 ug/l @ 810 cfm *
- Aerosol Concentration 10 ug/l @ 8,100 cfm *
- Generator Type: 1 to 6 Laskin Nozzles
- Compressed Air: 3 to 18 cfm @ 20 psi
- Aerosol Type: Polydispersed (Cold)
- Size: 10" L × 11" W × 9" H (25cm L × 28cm W × 23cm H)
- Weight-Pounds (lbs): 16 lbs.
- Weight-Kilograms (kg): 7.3 kg
- Electrical: (Not Required)
Applications
- Clean Rooms
- Laminar Flow Benches
- Biosafety Cabinets
- Glove Boxes
- HEPA Vacuum Cleaners
- HVAC Systems
- HEPA Filters
- ULPA Filters
- Negative Pressure Filtration Units
- Surgical Suites
- Nuclear Filter Banks
- Collective Protection Filters
Research and Development
Industries
- Pharmaceutical
- Food Processing
- Veterinary Medicine
- Laboratories
- Asbestos Abatement
- Heavy Metal Processors
- Nuclear Power and Fuel
- Hospitals
- Chemical Processing
- Certifiers
- NBC Defense Agencies
- Governmental Labs
- Filter Manufacturers
- Micro Electronic
- Electronic
- Biotechnology
- Micromechanics
* If more than 20 psig is used, the output concentration will increase and conversely, if less than 20 psig is used, the output concentration will decrease
* If using more than 2 nozzles, upstream concentration should be measured
关键词:尘埃粒子计数,悬浮粒子测试仪,颗粒分析,空气粒子,仪器仪表,净化工程,净化车间,净化设备,洁净车间,制药车间,制药机械,制药工程,浮游细菌采样器,风量仪,生物安全柜,净化工作台,洁净工作台,生物工程,生物器材,烘箱,培养箱,干燥箱,实验室设备,实验室工程,检测仪器,气溶胶发生器,气溶胶光度计,悬浮粒子发生器,悬浮粒子光度计,温湿度压差,记录仪,洁净采样车,传递窗,压差计,测振仪,辐照计,微生物检测,工程公司,净化公司,制药公司,生物公司,风淋室,货淋室,称量室,通风柜